環保專案成果報告查詢系統

專案計畫編號
經費年度	099
計畫經費	6,641 千元
專案開始日期	2010/11/12
專案結束日期	2011/12/31
專案主持人	卓啟弘
主辦單位	彰化縣環境保護局
承辦人	劉祥棋
執行單位	台灣曼寧工程顧問股份有限公司
專案分類	大氣空氣
中文關鍵字	最大增量反應性;加油站;揮發性有機物
英文關鍵字	Maximum Incremental Reactivity;Gas stations;Volatile organic compounds
協同主持人
共同主持人
計畫聯絡人	張泰華
計畫聯絡電話	04-8008070#
計畫聯絡信箱	hcliu@chepb.gov.tw

中文摘要	一、更新維護及擴充VOCs排放資料庫作業1.99/11/12~100/12/31共執行102家公私場所之資料更新清查作業，掌握78家86製程使用MIR物種之公私場所，物種以甲苯、二甲苯使用最廣泛，分別為甲苯51家496.674公噸、二甲苯24家67.593公噸。 2.執行102家清查作業後，粒狀污染物排放量為273.23公噸/年，硫氧化物排放量為1,258.12公噸/年，氮氧化物排放量為2,734.38公噸/年，揮發性有機物排放量為1,072.32公噸/年。二、行業法規揮發性有機物法規符合度查核作業 1.行業法規符合度(如：PU合成皮業、石化業、乾洗業、半導體業、汽車表面塗裝及膠帶業)，共查核37家，其中合發興業田中工廠暫時停工，其餘查核結果尚符合法規；另外，加油站法規符合度共查核170站(仁好加油站於100/08/30申請暫時停工)，其中有7站不符合，查核不符合對象皆已改善完成。三、非甲烷碳氫化合物(NMHC)、管道或周界異味官能測定或空氣污染物檢測及石化製程設備元件檢測作業 1.非甲烷碳氫化合物(NMHC)煙道檢測共完成執行6家10根次，其中錦懋興業、吉偉一廠、炎洲及尚鋒興業為執行防制設備效率驗證，而臺塑汽車彰化廠及矽品精密彰化廠為執行單一行業排放標準驗證，檢測結果均符合許可核定效率或行業法規排放標準規範。 2.管道或周界異味官能測定或空氣污染物檢測作業，排放管道之空氣污染物檢測11根次(檢測項目分別為PSN、甲苯及管道異味)及官能測定9點次，共執行20點、根次；其中排放管道粒狀污染物部分榮成紙業結果超過法規標準，而管道異味檢測部分帝綱瀝青未符合排放標準，官能測定部分同益未符合排放標準，不符合對象皆已進行裁處作業並改善完成。 3.石化製程設備元件抽測作業部分，共執行27家1萬100點次，其中世全塗料二廠檢測結果有5點次元件濃度達洩漏定義值(2,000ppm)，其餘檢測結果皆符合排放標準。 4.石化製程設備元件圍封試驗完成5點次採樣，對象為英全、匯春、臺灣化學及台塑摻配廠，檢測結果圍封試驗之係數/排放量皆低於目前現行各種計量方式。四、異味陳情案件之後續追蹤及複查作業 1.異味陳情案件後續追蹤及複查共複查25家次，其中亮亞、永福橡膠、臺灣化學、正新溪州廠、祺益、亨龍及帝綱瀝青均進行部分污染改善，改善方式包含設置集氣設備提高收集效率、設置防制設備、排放管道加高等改善措施；25家公私場所陳情次數由99年1~9月之418次減少為100年1~9月之188次，共減少230次。五、VOCs污染減量及改善查核作業 1.VOCs污染減量及改善共10家進行改善，包含友嘉興業、高北企業、永福橡膠、錦懋興業、亮亞科技、廣質、世全二廠、翔億、正昇印鐵及美利達等，改善方式包含新增集氣設備、防制設備、製程停止操作及製程改善等，整體減量67.25公噸。六、加油站空氣污染物排放檢測與管制工作 1.執行92站油氣回收設施功能檢測，氣油比平均合格率為92.7%，氣漏檢測合格率為94.5%。在稽查檢測12站對象中，不合格包含無憂、芳苑、員田及香山加油站，皆已裁處並改善完成；另外，對於不合格者，已限期改善並於改善後採無預警方式執行複測，共完成氣油比複測22站87槍，複測結果皆符合法規規範；在加油站減量部分，VOCs排放量削減共39.4公噸/年(99年11月~100年9月)。 2.進行明星加油站之新設加油站審核作業，已於100/02/17完成第一階段審查。 3.加油站FID檢測作業共執行10站373點次FID檢測，其中5家9點次達洩漏定義值(1,000ppm)規定，其餘檢測結果皆未達洩漏定義值；另外，針對濃度大於1,000ppm之元件要求改善，共減量0.69公噸。七、辦理其他相關作業 1.完成2場次說明會辦理，分別為「固定污染源異味管制法規及控制技術說明會」及「加油站油氣回收法規及設備維護訓練宣導說明會」。兩場次說明會出席人數皆符合合約規定。 2.協助環保局於100/04/22公告「彰化縣加油站加油槍空氣污染行為」，並於公告後執行80站次查核。
中文關鍵字	最大增量反應性;加油站;揮發性有機物

中文摘要

一、更新維護及擴充VOCs排放資料庫作業1.99/11/12~100/12/31共執行102家公私場所之資料更新清查作業，掌握78家86製程使用MIR物種之公私場所，物種以甲苯、二甲苯使用最廣泛，分別為甲苯51家496.674公噸、二甲苯24家67.593公噸。 2.執行102家清查作業後，粒狀污染物排放量為273.23公噸/年，硫氧化物排放量為1,258.12公噸/年，氮氧化物排放量為2,734.38公噸/年，揮發性有機物排放量為1,072.32公噸/年。二、行業法規揮發性有機物法規符合度查核作業 1.行業法規符合度(如：PU合成皮業、石化業、乾洗業、半導體業、汽車表面塗裝及膠帶業)，共查核37家，其中合發興業田中工廠暫時停工，其餘查核結果尚符合法規；另外，加油站法規符合度共查核170站(仁好加油站於100/08/30申請暫時停工)，其中有7站不符合，查核不符合對象皆已改善完成。三、非甲烷碳氫化合物(NMHC)、管道或周界異味官能測定或空氣污染物檢測及石化製程設備元件檢測作業 1.非甲烷碳氫化合物(NMHC)煙道檢測共完成執行6家10根次，其中錦懋興業、吉偉一廠、炎洲及尚鋒興業為執行防制設備效率驗證，而臺塑汽車彰化廠及矽品精密彰化廠為執行單一行業排放標準驗證，檢測結果均符合許可核定效率或行業法規排放標準規範。 2.管道或周界異味官能測定或空氣污染物檢測作業，排放管道之空氣污染物檢測11根次(檢測項目分別為PSN、甲苯及管道異味)及官能測定9點次，共執行20點、根次；其中排放管道粒狀污染物部分榮成紙業結果超過法規標準，而管道異味檢測部分帝綱瀝青未符合排放標準，官能測定部分同益未符合排放標準，不符合對象皆已進行裁處作業並改善完成。 3.石化製程設備元件抽測作業部分，共執行27家1萬100點次，其中世全塗料二廠檢測結果有5點次元件濃度達洩漏定義值(2,000ppm)，其餘檢測結果皆符合排放標準。 4.石化製程設備元件圍封試驗完成5點次採樣，對象為英全、匯春、臺灣化學及台塑摻配廠，檢測結果圍封試驗之係數/排放量皆低於目前現行各種計量方式。四、異味陳情案件之後續追蹤及複查作業 1.異味陳情案件後續追蹤及複查共複查25家次，其中亮亞、永福橡膠、臺灣化學、正新溪州廠、祺益、亨龍及帝綱瀝青均進行部分污染改善，改善方式包含設置集氣設備提高收集效率、設置防制設備、排放管道加高等改善措施；25家公私場所陳情次數由99年1~9月之418次減少為100年1~9月之188次，共減少230次。五、VOCs污染減量及改善查核作業 1.VOCs污染減量及改善共10家進行改善，包含友嘉興業、高北企業、永福橡膠、錦懋興業、亮亞科技、廣質、世全二廠、翔億、正昇印鐵及美利達等，改善方式包含新增集氣設備、防制設備、製程停止操作及製程改善等，整體減量67.25公噸。六、加油站空氣污染物排放檢測與管制工作 1.執行92站油氣回收設施功能檢測，氣油比平均合格率為92.7%，氣漏檢測合格率為94.5%。在稽查檢測12站對象中，不合格包含無憂、芳苑、員田及香山加油站，皆已裁處並改善完成；另外，對於不合格者，已限期改善並於改善後採無預警方式執行複測，共完成氣油比複測22站87槍，複測結果皆符合法規規範；在加油站減量部分，VOCs排放量削減共39.4公噸/年(99年11月~100年9月)。 2.進行明星加油站之新設加油站審核作業，已於100/02/17完成第一階段審查。 3.加油站FID檢測作業共執行10站373點次FID檢測，其中5家9點次達洩漏定義值(1,000ppm)規定，其餘檢測結果皆未達洩漏定義值；另外，針對濃度大於1,000ppm之元件要求改善，共減量0.69公噸。七、辦理其他相關作業 1.完成2場次說明會辦理，分別為「固定污染源異味管制法規及控制技術說明會」及「加油站油氣回收法規及設備維護訓練宣導說明會」。兩場次說明會出席人數皆符合合約規定。 2.協助環保局於100/04/22公告「彰化縣加油站加油槍空氣污染行為」，並於公告後執行80站次查核。

中文關鍵字

最大增量反應性;加油站;揮發性有機物

類型	檔名	檔案大小	說明	最新版公開日期
期末報告	99彰化縣VOCs調查及管制計畫執行成果.pdf	0MB		2012/2/1 上午 12:00:00

摘要	This year’s tasks include the updating, maintenance and expansion of the VOC database, checking of legal compliance on VOCs, follow-up and rechecking of odor complaint cases, checking of VOCs pollution reduction and improvement, auditing tests, paper review on new gas stations, function checking and propaganda of vapor recovery facility at gas stations. During the execution period, the EPA, EPB and many experts offered counsels and suggestions, making the tasks carried out as scheduled. The table below lists the executive summary of the Project’s tasks, the contents and detailed results of each of which are elaborated in the sections of this report. I. Updating, maintenance and expansion of the database for VOCs A. The operation updated and checked the documents at 102 organizations during 2010/11/12-2011/12/31 and grasped the use of MIR in 86 processes at 78 organizations, where toluene and xylene were most widely used, in 496.674 ton by 51 firms and 67.593 ton by 24 firms, respectively. B. After the inspection worked on 102 companies, the emission amount of particulate pollutants were 273.23 tons/year, sulfur oxides were 1,258.12 tons/year, nitrogen oxides were 2,734.38 tons/year, and volatile organic compounds (VOCs) were 1,072.32 tons/year. II. Industries laws and regulations degree of conformity inspection and control on volatile organic compounds A. For industrial compliance with the laws (e.g., PU leather factory, petrochemical plant, dry laundry, semiconductor plant, automotive surface coating shop and tape factory), 37 firms were checked. Among these, the Tianzhong plant of He Fa has suspended work and the remainders were found to comply with the laws. For gas station legal compliance, 170 stations were checked (Renhao Gas Station applied for suspension on 2011/08/30), of which seven were noncompliant, but all noncompliance was improved. III. Functional test of NMHC, ducts or peripheral odors, or air pollutants tests and petrochemical process equipment components tests A. For NMHC flue inspection, 10 tests were made at six firms; Paper Fabric Enterprises, Chi Wei#1 plant, Yem Chio and Sun Home Leather received control facility efficiency test, Changhua plant of Formosa Motors and Changhua plant of Siliconware Precision Industries received single industry emission standard test. The test results all proved compliant with the approved efficiency or the regulations on emission standards for the industry. B. In functional test of ducts or peripheral odors or air pollutants tests, 11 tests of air pollutants in emission ducts (PSN, toluene and flue odor) and 9 functional tests were conducted, resulting in a total of 20 tests. In emission of flue particles, Long Chen Paper was found with exceeding the mandate criteria, in flue odor test, Ti Kang Bitumen was noncompliant with the standards for emission and in sensual test, Tung Yi was noncompliant with the standards for emission; the noncompliance has all been dealt with and improvement completed. C. In component sampling test on petrochemical processing equipment, a total of 10,100 point-time was conducted at 27 firms; #2 plant of Shi Quan Paints was found with component concentration reaching the value for definition of leaking (2,000ppm) at five point-time; the remainders were all found to comply with the emission standards. D. Component envelopment test on petrochemical processing equipment was conducted five samplings at En Chuan, Full-Spring, Formosa Chemicals & Fibre Corporation and the Blending plant of Formosa Plastics; the test results had the envelopment test coefficients/emissions all below the current measurement in force. IV. Follow-up and reexamination of complaints of odors A. For follow-up and rechecking of odor complaint cases, 25 organization-time were conducted; Liang Ya, Yeong Fu Rubber, Formosa Chemicals & Fibre Corporation, Cheng Shin Rubber, Chi Yi, Heng Lung and Ti Kang Bitumen were undergoing partial pollution improvement, which included the methods of setting up gas collecting equipment to increase the efficiency in collection, setting up controlling equipment and elevating the emission flues. At the 25 organizations, the number of complaints received decreased by 230 times from 418 cases in Jan.-Sept. 2010 to 188 in Jan.-Sept. 2011. V. Checking of VOCs pollution reduction and improvement A. On VOC pollution reduction and improvement, ten firms, namely, Yu Great Industrial, Kao Pei, Yeong Fu Rubber, Paper Fabric Enterprises, Liang Ya, Gan Che, #2 plant of Shi Quan, Goodlot Enterprise, Cheng Shen Metallograthics And Canning and Merida, made improvement by incorporating additional gas collectors, controlling equipment, process halt and process improvement. Combined, the reduction was 67.25 ton. VI. Tests and control of air pollutants emission at gas station A. In vapor recovery facility function check at 92 gas stations, compliance rate with vapor-oil ratio was at average 92.7% and that with gas leakage test was 94.5%. Of 12 stations under auditing check, Wuyu, Fangyuan, Yuantian and Xiangshan Gas stations failed to pass and completed improvement after punishment. A total of 87 guns at 22 stations received vapor-oil ratio re-inspection without pre-notice given after failing to pass and timeframe for improvement was given; these all complied at the re-inspection. In emission reduction of gas station, VOC emission decreased by 39.4 ton/year (2010 Nov.-2011 Sept.) B. Completed the first stage of review of set-up of new Mingxing Gas Station on 2011/02/17. C. The flame ionization detector (FID) inspection on gas station checked for 373 times at ten stations, of which nine times at five stations were found with reaching the definition of leakage (1,000ppm), with the remainders not reaching. Required the components with concentration higher than 1,000ppm to improve; total reduction was 0.69 ton. VII. Other related operations A. Held two presentations, the “Presentation of controlling laws and control techniques on odors at stationery polluting source” and “Propaganda for regulations and equipment maintenance training on vapor recovery at gas stations”. The number of attendants at these presentations all met the provision of the contract. B. Assisted EPB in publishing “Air polluting actions at gas stations in Changhua County” on 2011/04/22 and, subsequently, carried out inspection 80 station-time.
英文關鍵字	Maximum Incremental Reactivity;Gas stations;Volatile organic compounds

摘要

This year’s tasks include the updating, maintenance and expansion of the VOC database, checking of legal compliance on VOCs, follow-up and rechecking of odor complaint cases, checking of VOCs pollution reduction and improvement, auditing tests, paper review on new gas stations, function checking and propaganda of vapor recovery facility at gas stations. During the execution period, the EPA, EPB and many experts offered counsels and suggestions, making the tasks carried out as scheduled. The table below lists the executive summary of the Project’s tasks, the contents and detailed results of each of which are elaborated in the sections of this report. I. Updating, maintenance and expansion of the database for VOCs A. The operation updated and checked the documents at 102 organizations during 2010/11/12-2011/12/31 and grasped the use of MIR in 86 processes at 78 organizations, where toluene and xylene were most widely used, in 496.674 ton by 51 firms and 67.593 ton by 24 firms, respectively. B. After the inspection worked on 102 companies, the emission amount of particulate pollutants were 273.23 tons/year, sulfur oxides were 1,258.12 tons/year, nitrogen oxides were 2,734.38 tons/year, and volatile organic compounds (VOCs) were 1,072.32 tons/year. II. Industries laws and regulations degree of conformity inspection and control on volatile organic compounds A. For industrial compliance with the laws (e.g., PU leather factory, petrochemical plant, dry laundry, semiconductor plant, automotive surface coating shop and tape factory), 37 firms were checked. Among these, the Tianzhong plant of He Fa has suspended work and the remainders were found to comply with the laws. For gas station legal compliance, 170 stations were checked (Renhao Gas Station applied for suspension on 2011/08/30), of which seven were noncompliant, but all noncompliance was improved. III. Functional test of NMHC, ducts or peripheral odors, or air pollutants tests and petrochemical process equipment components tests A. For NMHC flue inspection, 10 tests were made at six firms; Paper Fabric Enterprises, Chi Wei#1 plant, Yem Chio and Sun Home Leather received control facility efficiency test, Changhua plant of Formosa Motors and Changhua plant of Siliconware Precision Industries received single industry emission standard test. The test results all proved compliant with the approved efficiency or the regulations on emission standards for the industry. B. In functional test of ducts or peripheral odors or air pollutants tests, 11 tests of air pollutants in emission ducts (PSN, toluene and flue odor) and 9 functional tests were conducted, resulting in a total of 20 tests. In emission of flue particles, Long Chen Paper was found with exceeding the mandate criteria, in flue odor test, Ti Kang Bitumen was noncompliant with the standards for emission and in sensual test, Tung Yi was noncompliant with the standards for emission; the noncompliance has all been dealt with and improvement completed. C. In component sampling test on petrochemical processing equipment, a total of 10,100 point-time was conducted at 27 firms; #2 plant of Shi Quan Paints was found with component concentration reaching the value for definition of leaking (2,000ppm) at five point-time; the remainders were all found to comply with the emission standards. D. Component envelopment test on petrochemical processing equipment was conducted five samplings at En Chuan, Full-Spring, Formosa Chemicals & Fibre Corporation and the Blending plant of Formosa Plastics; the test results had the envelopment test coefficients/emissions all below the current measurement in force. IV. Follow-up and reexamination of complaints of odors A. For follow-up and rechecking of odor complaint cases, 25 organization-time were conducted; Liang Ya, Yeong Fu Rubber, Formosa Chemicals & Fibre Corporation, Cheng Shin Rubber, Chi Yi, Heng Lung and Ti Kang Bitumen were undergoing partial pollution improvement, which included the methods of setting up gas collecting equipment to increase the efficiency in collection, setting up controlling equipment and elevating the emission flues. At the 25 organizations, the number of complaints received decreased by 230 times from 418 cases in Jan.-Sept. 2010 to 188 in Jan.-Sept. 2011. V. Checking of VOCs pollution reduction and improvement A. On VOC pollution reduction and improvement, ten firms, namely, Yu Great Industrial, Kao Pei, Yeong Fu Rubber, Paper Fabric Enterprises, Liang Ya, Gan Che, #2 plant of Shi Quan, Goodlot Enterprise, Cheng Shen Metallograthics And Canning and Merida, made improvement by incorporating additional gas collectors, controlling equipment, process halt and process improvement. Combined, the reduction was 67.25 ton. VI. Tests and control of air pollutants emission at gas station A. In vapor recovery facility function check at 92 gas stations, compliance rate with vapor-oil ratio was at average 92.7% and that with gas leakage test was 94.5%. Of 12 stations under auditing check, Wuyu, Fangyuan, Yuantian and Xiangshan Gas stations failed to pass and completed improvement after punishment. A total of 87 guns at 22 stations received vapor-oil ratio re-inspection without pre-notice given after failing to pass and timeframe for improvement was given; these all complied at the re-inspection. In emission reduction of gas station, VOC emission decreased by 39.4 ton/year (2010 Nov.-2011 Sept.) B. Completed the first stage of review of set-up of new Mingxing Gas Station on 2011/02/17. C. The flame ionization detector (FID) inspection on gas station checked for 373 times at ten stations, of which nine times at five stations were found with reaching the definition of leakage (1,000ppm), with the remainders not reaching. Required the components with concentration higher than 1,000ppm to improve; total reduction was 0.69 ton. VII. Other related operations A. Held two presentations, the “Presentation of controlling laws and control techniques on odors at stationery polluting source” and “Propaganda for regulations and equipment maintenance training on vapor recovery at gas stations”. The number of attendants at these presentations all met the provision of the contract. B. Assisted EPB in publishing “Air polluting actions at gas stations in Changhua County” on 2011/04/22 and, subsequently, carried out inspection 80 station-time.

英文關鍵字

Maximum Incremental Reactivity;Gas stations;Volatile organic compounds